Wuxishi Da Tang Drying Equipment Factory
Home > Exhibition > Content
Horizontal dryer used in coal cakes
- May 19, 2017 -

Because the newly produced briquette water content is large, not easy to store and transport, horizontal dryer if the use of vertical dryer inside the briquette is very much broken, and the use of horizontal type dryer is basically no damage.
Horizontal dryer machine according to the pressure ball machine production design Patch dryer number of layers, long width, according to the production needs of flexible design to meet the customer's briquette drying needs.

Replacement of the type of coal dryer with the characteristics of the replica as a transport carrier, sieve plate (not ordinary steel mesh belt) use heat-resistant steel into a mesh, with high strength, easy deformation, good ventilation. Replacement on the free, easy to dry briquettes and briquette. Compared with the mesh belt in the dryer, it is not easy to deform due to gravity due to the high temperature and humidity environment, which eliminates the maintenance cost caused by the use of the mesh belt dryer.

Replaced briquette dryer with automatic tensioning device, horizontal dryer chain plate running smoothly, flip freely, thus solving the chain, card chain, deviation and so on.

Chain plate by the speed motor drive, according to the need to adjust the speed of operation, according to the characteristics of coal itself, control drying time, in order to achieve the best drying effect.

Horizontal type of coal dryer kiln body temperature display, easy to master and control the kiln temperature. Kiln inverting machine on both sides of the maintenance channel, easy to carry out maintenance testing equipment.

With the fire protection device, kiln head, kiln, kiln, with three thermocouple, flue inlet with smoke gate, once the mechanical failure, horizontal dryer immediately put down the gate, cut off the heat source to prevent the fire.

Using negative pressure cited wind, dust is small, uniform distribution of hot air, air inlet and chimney at the bottom of the ash pool, dust discharge standards, replica two with automatic screw ash removal device, simple and convenient. Positive pressure blast, dust, the production site pollution is serious, and cloth duct easily blocked. Negative pressure cited air kiln exhaust temperature 100 , dust content is small, induced draft fan long life, low operating costs.

Designed from the end of the low-temperature area of the ball, the ball out of the ball, the briquettes from the low temperature gradient heating, high temperature zone gradient heating, to avoid the formation of 8-10% moisture after the briquettes due to rapid heat and crack, burst, The This is designed for the characteristics of briquette itself, effectively improving the quality of the production of briquette.

Hot stove heating using chain furnace automatic heating equipment, automatic coal, automatic slag removal, high thermal efficiency, coal to adapt to wide, clean and environmentally friendly, save time and labor.

We look forward to cooperating with partners from all the world to build win-win cooperation relationship in long term. If you are interested in our products,please contact us!
Wuxishi Da Tang Drying Equipment Factory
Contact: Zhiming Tang
Mob: +86-13606174509
Tel: +86-510-83388557
Fax: +86-510-83581877
Email: dtgz168@126.com
Website: http://www.datang-dryer.com